|
blacrubi 01-30-2010, 03:10 PM one of my budds got stuck today and i turned my lockers on in my rubicon to pull him out after i pulled him out the front locker will not turn off! ive tried everything and it is still on the light just blinks. any way to manually turn in off other than the button? i drove 2 miles home going 5mph and its still blinkin! any help greatly appreciated! johnmcd 01-30-2010, 03:16 PM Not100% sure buthave you tried/ checked the relay's? blacrubi 01-30-2010, 03:21 PM relays are fine the wires still have current coming through them after the relay. and the plug at the diff still has current comming to it. idk what else to check. Never Monday 01-30-2010, 04:06 PM what happens if you shift to 4 hi or 2wd? can you feel the front is locked? blacrubi 01-30-2010, 04:17 PM yes the light continues to blink and the front is definetly still locked no matter what drive the transfer case in. i unpluged it and pluged it back in checked the relays and the rear locker is working fine so i know the air pumps are fine. Wild Hare 01-30-2010, 05:32 PM dont they automatically shut off when you exceed 30mph stealthjeep1 01-30-2010, 06:16 PM dont they automatically shut off when you exceed 30mph x2 blacrubi 01-30-2010, 06:27 PM yes they are susposed to but for some reason its stuck on ive gone 30 and it just keeps blinkin. idk... CtChevy 01-30-2010, 06:41 PM Ok that is an air locker correct, well shouldnt it disconnect if you take the air off. if it doesnt then something is bound up inside the diff, sounds like you will have to pull the cover and take a look. Jeffb_79 01-30-2010, 10:09 PM If you pull the air hose, it should shut off. Either way, you need to pull the cover off and take a look to see what's going on. 2003_ram 01-30-2010, 11:29 PM If you pull the air hose, it should shut off. Either way, you need to pull the cover off and take a look to see what's going on. x2. Easy enough to do. Matt2001TJ 01-31-2010, 10:10 AM Ok that is an air locker correct, well shouldnt it disconnect if you take the air off. if it doesnt then something is bound up inside the diff, sounds like you will have to pull the cover and take a look.AGREED,...Also, there are two air pumps. Disconnect the front one. If it still will not disengage then pull the cover and see what you have going on because at that point there is a bind on something. http://i663.photobucket.com/albums/uu358/rebelchapter4x4/THEREBELLOGOBESTVERSION.jpg Jeep07 01-31-2010, 11:21 AM Put the tcase in 2wd and jack the front up and spin the tires manually and see if you can get it to release. If not follow the other instructions on here. ogreshooter 02-01-2010, 01:33 AM Probably junk. Pull the axle, ship it to me, I will send you my D30 to replace it. :grinpimp: blacrubi 02-01-2010, 07:02 AM i jacked it up last night and took the cover off and there was nothing i could see from there to be keeping it locked. i tried to wedge one tire and spin the other and its still locked. i disconnected both pumps and switched them and the pump that was originally for the front was connected to the rear it still worked fine. so ive come to the conclusion that it has to be something internal within the locker. the bad thing about the whole situation is that i already traded the rubi d44s for a set of 78 ford tons:grinpimp:and ive already picked up the tons. so i have to fix this!!! rubikrawler 02-16-2010, 06:46 PM If you need a d44 rubicon locker still let me know.. | |